2002 Tiffin Allegro: common problems

Owners of the 2002 Tiffin Allegro filed 10 complaints with NHTSA, most often about electrical system and equipment. Details by component below, with sources.

Key figures

Owner complaints: 10

What fails most often

1 Electrical system 30% of all complaints
2 Equipment 30% of all complaints
3 Seat belts 30% of all complaints
4 Visibility 30% of all complaints
5 Engine and cooling 20% of all complaints
6 Structure 20% of all complaints
7 Tires 20% of all complaints
8 Exterior lighting 10% of all complaints

Circle size and colour show each component’s share of NHTSA complaints. Schematic only, not a drawing of the exact model.

Electrical system: 3 complaints (30% of all).
Equipment: 3 complaints (30% of all).
Seat belts: 3 complaints (30% of all).
Visibility: 3 complaints (30% of all).
Engine and cooling: 2 complaints (20% of all).

Symptoms owners describe

How many of the 10 NHTSA complaints mention each symptom (automatic count from complaint text; one complaint can mention several).

seat belts3 · 30%
A/C or heater2 · 20%
door locks, latches, handles1 · 10%
rollaway, parking brake1 · 10%
smoke, burning smell, fire1 · 10%
tires: bulges, blowouts1 · 10%

Components owners complain about

Component	Owner complaints	involving a crash	Technical service bulletins (TSB)
Electrical system	3	0	0
Equipment	3	0	0
Seat belts	3	0	0
Visibility	3	0	0
Engine and cooling	2	0	0
Structure	2	0	0
Tires	2	0	0
Exterior lighting	1	0	0
Latches, locks, linkages	1	0	0
Parking brake	1	0	0
Other	2	0	0

What owners report

Short excerpts of NHTSA complaints in the original wording. These are owner statements not verified by NHTSA; personal data removed.

Workhorse chassis automatic parking brake locked without warning and without pulling the auxiliary button. Would not release and I had to go under the vehicle and disconnect it.
Parking brake · 2006-05-31 · NHTSA complaint #10158638
In 2000 2 tires blew out. In april 2005 two more tires blew out. All together 4 tires blew out of the original 6 tires. He had motor home and tires regularly maintained. He was driving at the time of both incidents. The first time one tire blew out, and he probably hadn't driven 50 miles when the other tire blew out.
Tires · 2005-05-23 · NHTSA complaint #10121944
Seat belt inoperative/failure twice, once after repaired. Windshields (2) replace twice due to stress breakage. Overhead a/c blows fuses, because of shortage, fuse panel located under closet over the proppane tank. If panel fails then fire could cause death or injury.
Electrical system · 2005-04-11 · NHTSA complaint #10116749
2002 tiffin allegro has problems with windshield wipers, seat belt malfunctioned, and door locks. The consumer was unable to latch the seat belt, the motor unit of the windshield wipers was completely detached from the body, both windshields broke due to stress.
Electrical system · 2005-04-08 · NHTSA complaint #10117504
Tiffin motorhome problems experience with rv drivers seat belt , both windshield wipers and electrical system. Vehicle warped and misaligned body chassis. The vehicle overhead a/c failed. The 20 amp fuse blew intermittently when the consumer tried to use the a/c.
Electrical system · 2005-03-14 · NHTSA complaint #10111352
On february 23, 2004 the right rear inner dual tire blew out, and separated while driving 65 mph. There was some extensive damage to the rear fender.
Tires · 2004-03-15 · NHTSA complaint #10063170
Vehicle has cut off while driving on several occasions. Feel free to provide any further information.
Engine and cooling · 2002-08-13 · NHTSA complaint #8016076
An on going problem with the turn signal continuity failing to operate. Vehicle been to the dealer on five occasions, and the problem still reoccurring. Feel free to provide any further information.
Exterior lighting · 2002-08-13 · NHTSA complaint #8016069

When owners complained

NHTSA complaints by filing year. The peak shows at what age the problems show up most.

20024
20041
20054
20061

Comparison

By complaint count this model year ranks 10,921 of 36,656 model years in the NHTSA data (top 30% most complained about).

On average one model year of the Allegro has 3 complaints (39 years in the data). This year has 10, above average.

What to check before buying

Electrical system. Scan all modules, test the battery and alternator, inspect connectors near the impact zone.
Seat belts. Belt pretensioners after airbag deployment, SRS codes.
Visibility. Wipers, mirrors, defrosters, cracked glass.
Engine and cooling. Radiator and fan after a frontal hit, coolant level and condition, overheating.

Questions and answers

What are the most common problems with the 2002 Tiffin Allegro?

Owner complaints to NHTSA most often mention: electrical system, equipment, seat belts. Total complaints: 10. The most frequent symptoms in complaint texts: seat belts (30%), A/C or heater (20%), door locks, latches, handles (10%).

How many service bulletins (TSB) were issued for the 2002 Tiffin Allegro?

NHTSA lists 0 manufacturer service bulletins for this year. A bulletin tells dealers how to diagnose or fix a known issue; it is not a recall.

Should I buy a 2002 Tiffin Allegro from a US auction?

Owner complaints describe defects, not crash damage. Before bidding, check the components listed above and review the lot photos: VinWind builds a report of visible and hidden damage by VIN.

Read also

Sources: public NHTSA data (USA): service bulletins and owner complaints; YouTube: links to videos credited to their authors. Complaints are owner statements not verified by NHTSA, and describe defects rather than crash damage. Data updated 2026-11-05.